2004 Alfa Romeo 166

Nearside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii))

Nearside Rear Exhaust has a major leak of exhaust gases (6.1.2 (a))

Heavy surface corrosion to rear chassis legs

Nearside Front Integral body structure is corroded but structural rigidity is not significantly reduced (6.1.1 (c) (i))

Nearside Front Outer Drive shaft joint constant velocity boot severely deteriorated (6.1.7 (g) (i))

Nearside Rear Integral body structure is corroded but structural rigidity is not significantly reduced (6.1.1 (c) (i))

Offside Front Integral body structure is corroded but structural rigidity is not significantly reduced (6.1.1 (c) (i))

Offside Front Outer Drive shaft joint constant velocity boot severely deteriorated (6.1.7 (g) (i))

Offside Rear Integral body structure is corroded but structural rigidity is not significantly reduced (6.1.1 (c) (i))

Anti-lock braking system warning lamp indicates an ABS fault (1.6 (b))

Nearside Front Position lamp not working (4.2.1 (a) (ii))

Offside Front Headlamp aim too low (4.1.2 (a))

Offside Rear Position lamp not working (4.2.1 (a) (ii))

Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii))

Rear Brakes imbalanced across an axle Axle 2 (1.2.1 (b) (i))

Rear Exhaust system insecure (6.1.2 (a))

Rear Rear fog lamp not working (4.5.1 (a) (ii))

Service brake efficiency below requirements (1.2.2 (a) (i))

Front Brakes imbalanced across an axle by more than 50% Axle 1 (1.2.1 (b) (ii)) DANGEROUS

Offside Front Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

Brake pipe corroded, covered in grease or other material (1.1.11 (c))

Exhaust mounting defective (6.1.2 (a))

Front Anti-roll bar ball joint has slight play both (5.3.4 (a) (i))

Front Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

Front Brake hose has slight corrosion to ferrule both (1.1.12 (f) (i))

Front Suspension arm ball joint has slight play both (5.3.4 (a) (i))

Front Suspension arm pin or bush worn but not resulting in excessive movement both (5.3.4 (a) (i))

Nearside Front Inner Drive shaft joint constant velocity boot severely deteriorated (6.1.7 (g) (i))

Rear spring and top mount corroded but not seriously damaged

corrosion to sill outside prescribed area

general under the body corrosion

Brake hose has slight corrosion to ferrule both front (1.1.12 (f) (i))

Brake pipe corroded, covered in grease or other material both front caliper brake pipes (1.1.11 (c))

Exhaust mounting defective (6.1.2 (a))

Front Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

Offside Front Brake pipe corroded, covered in grease or other material (1.1.11 (c))

Suspension arm ball joint has slight play both front, lower arms (5.3.4 (a) (i))

Suspension arm pin or bush worn but not resulting in excessive movement both front, lower arms (5.3.4 (a) (i))

Tyre slightly damaged/cracking or perishing both front (5.2.3 (d) (ii))

both front tyres wearing on inner edges

corrosion to sills but outside of prescribed areas

general underside corrosion

nearside inner cv boot starting to leak grease

rear springs and top mounts corroded but not seriously weakened

Offside Rear Tyre has a cut in excess of the requirements deep enough to reach the ply or cords (5.2.3 (d) (i))

Brake hose has slight corrosion to ferrule both front (1.1.12 (f) (i))

Brake pipe corroded, covered in grease or other material both front caliper brake pipes (1.1.11 (c))

Exhaust mounting defective (6.1.2 (a))

Front Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

Offside Front Brake pipe corroded, covered in grease or other material (1.1.11 (c))

Suspension arm ball joint has slight play both front, lower arms (5.3.4 (a) (i))

Suspension arm pin or bush worn but not resulting in excessive movement both front, lower arms (5.3.4 (a) (i))

Tyre has a cut but not deep enough to reach the ply or cords both front and nearside rear (5.2.3 (d) (i))

both front tyres wearing on inner edges

corrosion to sills but outside of prescribed areas

general underside corrosion

nearside inner cv boot starting to leak grease

rear springs and top mounts corroded but not seriously weakened

Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

Brake pipe corroded, covered in grease or other material Rear sections of front to rear pipes (1.1.11 (c))

Exhaust has a minor leak of exhaust gases Flexi-sections (6.1.2 (a))

Offside Rear Service brake binding but not excessively (1.2.1 (f))

Offside Rear Tyre slightly damaged/cracking or perishing (5.2.3 (d) (ii))

Rear nearside tyre slightly perished on outer sidewall

Rear offside inner sidelight not working

Suspension arm ball joint has slight play Both front, lower arms (5.3.4 (a) (i))

x1 exhaust hanger broken away - exhaust still secure

Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

Brake pipe corroded, covered in grease or other material Rear sections of front to rear pipes (1.1.11 (c))

Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h))

Exhaust has a minor leak of exhaust gases Flexi-sections (6.1.2 (a))

Offside Rear Service brake binding but not excessively (1.2.1 (f))

Offside Rear Tyre slightly damaged/cracking or perishing (5.2.3 (d) (ii))

Offside Stop lamp(s) not working (4.3.1 (a) (ii))

Rear nearside tyre slightly perished on outer sidewall

Rear offside inner sidelight not working

Suspension arm ball joint has slight play Both front, lower arms (5.3.4 (a) (i))

x1 exhaust hanger broken away - exhaust still secure

Nearside Front Lower Suspension arm pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

Offside Front Lower Suspension arm pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

Offside Rear Tyre slightly damaged/cracking or perishing (5.2.3 (d) (ii))

Oil leak, but not excessive (8.4.1 (a) (i))

Rear Brake disc worn, pitted or scored, but not seriously weakened both (1.1.14 (a) (ii))

Rear Coil spring corroded both (5.3.1 (b) (i))

Front Windscreen wiper does not clear the windscreen effectively (3.4 (b) (ii))

Nearside Front Lower Suspension arm pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

Offside Front Lower Suspension arm pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

Offside Rear Tyre slightly damaged/cracking or perishing (5.2.3 (d) (ii))

Oil leak, but not excessive (8.4.1 (a) (i))

Rear Brake disc worn, pitted or scored, but not seriously weakened both (1.1.14 (a) (ii))

Rear Coil spring corroded both (5.3.1 (b) (i))

Front Anti-roll bar corroded but not seriously weakened (5.3.3 (b) (i))

Front Brake disc worn, pitted or scored, but not seriously weakened both (1.1.14 (a) (ii))

Front Brake pad(s) wearing thin both (1.1.13 (a) (ii))

Front Suspension arm corroded but not seriously weakened both (5.3.3 (b) (i))

Rear Anti-roll bar corroded but not seriously weakened (5.3.3 (b) (i))

Rear Sub-frame pin or bush worn but not resulting in excessive movement both offside and nearside (5.3.4 (a) (i))

Brakes imbalanced across an axle 40% (1.2.1 (b) (i))

Nearside Front Upper Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii))

Offside Front Coil spring fractured or broken (5.3.1 (b) (i))

Front Anti-roll bar corroded but not seriously weakened (5.3.3 (b) (i))

Front Brake disc worn, pitted or scored, but not seriously weakened both (1.1.14 (a) (ii))

Front Brake pad(s) wearing thin both (1.1.13 (a) (ii))

Front Suspension arm corroded but not seriously weakened both (5.3.3 (b) (i))

Rear Anti-roll bar corroded but not seriously weakened (5.3.3 (b) (i))

Rear Sub-frame pin or bush worn but not resulting in excessive movement both offside and nearside (5.3.4 (a) (i))

Nearside Front Brake hose has slight corrosion to ferrules (3.6.B.4e)

Nearside Front brake disc worn, pitted or scored, but not seriously weakened (3.5.1i)

Offside Front Brake hose has slight corrosion to ferrules (3.6.B.4e)

Offside Front brake disc worn, pitted or scored, but not seriously weakened (3.5.1i)

Offside Outer Front constant velocity joint gaiter deteriorated, but preventing the ingress of dirt (2.5.C.1a)

Offside Rear position lamp(s) has light sources not illuminating, but not more than 50% (1.1.A.3b)

Rear Brake pipe slightly corroded both (3.6.B.2c)

Rear coil spring corroded both (2.4.C.1b)

front brake fluctuating, but not excessively both (3.7.B.3)

Front Brake pad(s) wearing thin (3.5.1g)

Front brake disc worn, pitted or scored, but not seriously weakened (3.5.1i)

Offside Rear position lamp(s) has light sources not illuminating, but not more than 50% (1.1.A.3b)

Rear Brake pipe slightly corroded (3.6.B.2c)

Rear Exhaust has a minor leak of exhaust gases (7.1.2)

Rear coil spring corroded (2.4.C.1b)

front brake fluctuating, but not excessively (3.7.B.3)

Nearside Front Brake pipe excessively corroded (3.6.B.2c) DANGEROUS

Front Brake pad(s) wearing thin (3.5.1g)

Front brake disc worn, pitted or scored, but not seriously weakened (3.5.1i)

Nearside Headlamp aim too low (1.8)

Offside Rear position lamp(s) has light sources not illuminating, but not more than 50% (1.1.A.3b)

Rear Brake pipe slightly corroded (3.6.B.2c)

Rear Exhaust has a minor leak of exhaust gases (7.1.2)

Rear coil spring corroded (2.4.C.1b)

front brake fluctuating, but not excessively (3.7.B.3)

N/S/R Tyre Old & Perished!

Nearside Front Brake pipe slightly corroded (3.6.B.2c)

Nearside Front Tyre worn close to the legal limit (4.1.E.1)

Nearside Rear Tyre worn close to the legal limit (4.1.E.1)

Offside Front Tyre worn close to the legal limit (4.1.E.1)

Brakes imbalanced requirements only just met. It would appear that the braking system requires adjustment or repair. (3.7.B.5b)

Nearside Front Suspension arm rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Nearside Rear Tyre worn close to the legal limit (4.1.E.1)

Offside Front Suspension arm rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Offside Front suspension has slight play in a lower suspension ball joint (2.5.B.1a)

Brakes imbalanced requirements only just met. It would appear that the braking system requires adjustment or repair. (3.7.B.5b)

Headlamp aim too low and too far to the left. (1.8)

Nearside Front Suspension arm rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Nearside Rear Tyre worn close to the legal limit (4.1.E.1)

Offside Front Suspension arm rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Offside Front suspension has slight play in a lower suspension ball joint (2.5.B.1a)

front brake discs corroded

rear braked discs pitted and grooved

Exhaust has part of the system slightly deteriorated (7.1.1a)

rear exhaust heat sheild loose

Nearside Front Upper Suspension arm has excessive play in a pin/bush (2.4.G.2)

Nearside Front coil spring fractured (2.4.C.1a)

Nearside Stop lamp not working (1.2.1b)

Nearside rear parking brake recording little or no effort (3.7.B.6a)

Offside rear parking brake recording little or no effort (3.7.B.6a)

Parking brake: efficiency below requirements (3.7.B.7)

Offside Front coil spring fractured (2.4.C.1a) DANGEROUS