1993 Chevrolet Astro

Anti-roll bar pin or bush worn but not resulting in excessive movement All (5.3.4 (a) (i))

Brake pipe corroded, covered in grease or other material All (1.1.11 (c))

Chassis/subframes/suspension arms corroded

Front Play in steering rack inner joint(s) Both ()

Front Suspension arm ball joint has slight play Both (5.3.4 (a) (i))

Inner and outer sills corroded

Suspension arm pin or bush worn but not resulting in excessive movement All (5.3.4 (a) (i))

Underbody corroded

Brake pipe corroded, covered in grease or other material front to rear (1.1.11 (c))

Front Brake disc worn, pitted or scored, but not seriously weakened both (1.1.14 (a) (ii))

Nearside Front Lower Suspension arm ball joint dust cover severely deteriorated (5.3.4 (b) (i))

Nearside Front Lower Suspension arm pin or bush worn but not resulting in excessive movement rear bushes (5.3.4 (a) (i))

Nearside Rear Seat belt anchorage prescribed area is corroded but not considered excessive sill (7.1.1 (a) (i))

Offside Front Lower Suspension arm ball joint dust cover severely deteriorated (5.3.4 (b) (i))

Offside Front Lower Suspension arm pin or bush worn but not resulting in excessive movement rear bushes (5.3.4 (a) (i))

Offside Rear Seat belt anchorage prescribed area is corroded but not considered excessive sill (7.1.1 (a) (i))

general corrosion to chassis

Front Registration plate does not conform to the specified requirements (0.1 (d))

Nearside Front passenger door cannot be opened from outside the vehicle (6.2.3 (a))

Nearside Prop shaft joint constant velocity boot no longer prevents the ingress of dirt (6.1.7 (g) (ii))

Nearside Tyre has a cut in excess of the requirements deep enough to reach the ply or cords (5.2.3 (d) (i))

Offside Front Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii))

Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength bump stop chassis (5.3.6 (a) (i))

Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner sill (5.3.6 (a) (i))

Offside Parking brake inoperative on one side (1.4.1 (a))

Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength chassis (5.3.6 (a) (i))

Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner sill (5.3.6 (a) (i))

Parking brake efficiency below requirements (1.4.2 (a) (i))

Nearside Front Position lamp light intensity obviously reduced (4.2.3 (a) (i))

Nearside Suspension arm ball joint dust cover severely deteriorated (5.3.4 (b) (i))

Offside Front Position lamp light intensity obviously reduced (4.2.3 (a) (i))

Nearside Front Lower Suspension component ball joint has slight play (5.3.4 (a) (i))

Offside Front Lower Seat belt anchorage prescribed area is corroded but not considered excessive (7.1.1 (a) (i))

Rear registration border is just on minimum reqiirement

rear load deck loaded with stuff

rear seats not fitted at time of test

slight exhaust blow in front area's

Front Registration plate does not conform to the specified requirements (0.1 (d))

Front Registration plate insecure (0.1 (a))

Nearside Front Lower Seat belt anchorage prescribed area strength or continuity significantly reduced inner sill (7.1.1 (a) (i))

Nearside Rear reflector missing (4.8.2 (a) (ii))

Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c))

Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i))

Offside Rear reflector missing (4.8.2 (a) (ii))

Offside Windscreen washer provides insufficient washer liquid (3.5 (a))

Nearside Front Lower Suspension component ball joint has slight play (5.3.4 (a) (i))

Offside Front Lower Seat belt anchorage prescribed area is corroded but not considered excessive (7.1.1 (a) (i))

Rear registration border is just on minimum reqiirement

rear load deck loaded with stuff

rear seats not fitted at time of test

slight exhaust blow in front area's

Offside Rear Brake pipe corroded, covered in grease or other material (1.1.11 (c))

battery loose but secure

fuel cap seal perished

no seats fitted in the rear at time of test

outer sills and various other area's corroded

park brake only just met required limits

Brake performance not tested major fluid leak (1.2.1 (g))

Nearside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i))

Nearside Side repeater missing (4.4.1 (a) (ii))

Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength chassis (5.3.6 (a) (i))

Offside Side repeater missing (4.4.1 (a) (ii))

Rear fog lamp not working (4.5.1 (a) (ii))

Nearside Rear Brake pipe leaking on a hydraulic braking system (1.1.11 (b) (ii)) DANGEROUS

Offside Front Tyre tread depth below requirements of 1.6mm (5.2.3 (e)) DANGEROUS

Offside Rear Brake pipe corroded, covered in grease or other material (1.1.11 (c))

battery loose but secure

fuel cap seal perished

no seats fitted in the rear at time of test

outer sills and various other area's corroded

Rear Brake pipe slightly corroded (3.6.B.2c)

front headlamp images visible but deteriorated

rear light outputs faded

various areas of corrosion to underside and over suspension

Nearside Front Sub-frame attachment bracket/mounting fractured rearmost (2.4.G.1)

Nearside Front Sub-frame attachment rubber mounting bonding deteriorated resulting in excessive movement rearmost (2.4.G.2)

Offside Rear Brake pipe inadequately clipped (3.6.B.1)

Offside Front Sub-frame attachment rubber mounting deteriorated resulting in excessive movement forward most (2.4.G.2) DANGEROUS

Offside Front Sub-frame corroded and seriously weakened forward most (2.4.G.1) DANGEROUS

Rear Brake pipe slightly corroded (3.6.B.2c)

front headlamp images visible but deteriorated

rear light outputs faded

various areas of corrosion to underside and over suspension

both images fading

nearside brake hose perished

offside front lower arm corroded

slight lift in front lower ball joints

Nearside Rear Leaf spring fractured (2.4.B.1a)

Offside Front Drag link end ball joint has excessive play steering arm (2.2.B.1f)

Offside Rear Suspension component mounting prescribed area is excessively corroded chassis leg (2.4.A.3)

Parking brake: efficiency below requirements (3.7.C.1b)

Rear Suspension has inadequate clearance with the bump stop bot rear shackles (2.4.A.1a)

Service brake: efficiency below requirements (3.7.C.1a)

Windscreen washer provides insufficient washer liquid (8.2.3)

battery light lit

both images fading

nearside front brake hose perished

offside front lower arm corroded

slight lift in nearside front ball joints

some corrosion and wear to front steering arms

Nearside Front Suspension component mounting prescribed area is excessively corroded inner chassis section (2.4.A.3)

some corrosion and wear to front steering arms

Towbar retaining device missing (6.6.3a)

nearside front tyre close to limit

slight corrosion to underside

slight play in offside steering idler

nearside front tyre close to limit

slight corrosion to underside

slight play in offside steering idler

nearside rear leaf spring slightly splayed

rear seats not fitted at time of test

slight play and lift in offside steering idler

water pipes leaking by fuel filler pipes

Battery insecure (1.9.1)

Nearside Front Lower Electrical wiring damaged and bare wires exposed (1.9.2c)

Nearside Rear Suspension component mounting prescribed area is excessively corroded (2.4.A.3)

Nearside Rear position lamp(s) incorrect colour (1.1.A.3e)

Nearside Stop lamp emits other than a steady red light (1.2.1e)

Offside Front Brake hose excessively damaged (3.6.B.4d)

Offside Headlamp aim too low and too far to the left. (1.8)

Offside Rear Leaf spring shackle bracket loose (2.4.B.6a)

Offside Rear Suspension component mounting prescribed area is excessively corroded (2.4.A.3)

Offside Rear position lamp(s) incorrect colour (1.1.A.3e)

Offside Side repeater insecure (1.4.A.2b)

Offside Stop lamp emits other than a steady red light (1.2.1e)

Offside Stop lamp not working (1.2.1b)

Rear registration plate insecure (6.3.1b)

Registration plate lamp not working (1.1.C.1d)

nearside rear leaf spring slightly splayed

rear seats not fitted at time of test

slight play and lift in offside steering idler

water pipes leaking by fuel filler pipes

Exhaust has a minor leak of exhaust gases (7.1.2)

Front Suspension component mounting prescribed area is corroded but not considered excessive (2.4.A.3)

Rear Suspension component mounting prescribed area is corroded but not considered excessive (2.4.A.3)

Rear position lamp(s) slightly discoloured (1.1.A.3e)

Steering system has slight free play detected at steering wheel (2.2.A.1a)

front tyres perished

no rear seats fitted

steering column lower bush worn

Nearside Front Ball joint has excessive play (2.2.B.1f)

Nearside Front Suspension component mounting prescribed area is excessively corroded (2.4.A.3)

Nearside rear brake recording little or no effort (3.7.B.5a)

Offside Front Suspension component mounting prescribed area is excessively corroded (2.4.A.3)

Offside Rear Suspension component mounting prescribed area is excessively corroded (2.4.A.3)

Offside rear brake recording little or no effort (3.7.B.5a)

Parking brake lever has no reserve travel (3.1.6b)

Service brake: efficiency below requirements (3.7.B.7)

Exhaust has a minor leak of exhaust gases (7.1.2)

Front Suspension component mounting prescribed area is corroded but not considered excessive (2.4.A.3)

Rear Suspension component mounting prescribed area is corroded but not considered excessive (2.4.A.3)

Rear position lamp(s) slightly discoloured (1.1.A.3e)

Steering system has slight free play detected at steering wheel (2.2.A.1a)

front tyres perished

no rear seats fitted

steering column lower bush worn

battery insecure

exhaust has slight blow on box

front brake hoses perished

heater pipes leaking

hiss from behind dash when engine running

long travel on park brake

offside headlamp on max limits to the left

rear seats were not fitted when presented for retest

Centre Rear Seat belt damaged sufficient to significantly weakened the webbing (5.2.2a)

Front registration plate not fixed vertically, or as close to vertical as is reasonably practical (6.3.2c)

Nearside Front Front suspension has excessive play in a lower suspension ball joint (2.5.B.1a)

Nearside Front Upper Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt (2.4.G.2)

Nearside Rear Leaf spring anchor bracket cracked (2.4.B.6b)

Nearside Rear Suspension spring mounting prescribed area is excessively corroded (2.4.A.3)

Offside Rear Leaf spring anchor bracket fractured (2.4.B.6b)

Offside Rear Leaf spring anchor bracket loose (2.4.B.6a)

Offside Rear Suspension spring mounting prescribed area is excessively corroded (2.4.A.3)

Offside Rear position lamp(s) incorrect colour (1.1.A.3e)

battery insecure

exhaust has slight blow on box

front brake hoses perished

heater pipes leaking

hiss from behind dash when engine running

long travel on park brake

offside headlamp on max limits to the left

Front Brake pad(s) wearing thin (3.5.1g)

both outer sill corroded and holed and inner sill holed

corossion to fuel return pipes

no passenger front seat fitted when tested

Front registration plate obscured (6.3.1d)

Nearside Front Leaf spring anchor bracket loose (2.4.B.6a)

Nearside Front Tyre tread depth below requirements of 1.6mm (4.1.E.1)

Nearside Rear Leaf spring anchor bracket loose (2.4.B.6a)

Offside Front Steering pivot point has excessive play (2.2.B.1g)

Offside Front Tyre has ply or cords exposed (4.1.D.1b)

Offside Rear Leaf spring shackle bracket fractured (2.4.B.6b) DANGEROUS

Front Brake pad(s) wearing thin (3.5.1g)

both outer sill corroded and holed and inner sill holed

corossion to fuel return pipes

both outer sills and nearside inner sill corroded and holed. out of prescribed area and not affecting suspension, steering,seatbelts or braking

galloping oil leak from filter housing

Both rear tyres perished

Small crack in windscreen noted out side zone A

Nearside Front Brake pad(s) less than 1.5 mm thick (3.5.1g)

Nearside Front Suspension component mounting prescribed area is excessively corroded (2.4.A.3)

Nearside Front brake disc in such a condition that it is seriously weakened (3.5.1i)

Nearside Headlamp aim beam image kick up to the offside (1.8)

Nearside Rear Suspension component mounting prescribed area is excessively corroded (2.4.A.3)

Offside Front position lamp(s) not working (1.1.A.3b)

Offside Headlamp aim beam image kick up to the offside (1.8)

Offside Headlamp insecure (1.7.3)

Offside Rear Suspension component mounting prescribed area is excessively corroded (2.4.A.3)

Parking brake: efficiency below requirements (3.7.C.1b)

Nearside Front Drag link end ball joint has excessive play (2.2.B.1f) DANGEROUS

Offside Front Drag link end ball joint has excessive play (2.2.B.1f) DANGEROUS

Both rear tyres perished

Offside Front Brake pad(s) wearing thin (3.5.1g)

Offside Front brake disc worn, pitted or scored, but not seriously weakened (3.5.1i)

Small crack in windscreen noted out side zone A

Emissions not tested (7.0)

Nearside Front Headlamp aim beam image kick up to the offside (1.8)

Nearside Front Windscreen has damage to an area in excess of a 10mm circle within zone 'A' (8.3.1a)

Nearside Rear Hazard warning lamps not flashing in phase, with ignition off (1.4.B.1f)

Offside Front Exhaust has a major leak of exhaust gases (7.1.2)

Offside Front Headlamp aim beam image kick up to the offside (1.8)

Offside Rear Rear fog lamp missing (1.3.2a)

Parking brake: efficiency below requirements (3.7.C.1b)

Windscreen washer provides insufficient washer liquid (8.2.3)

Nearside Front Lower Suspension arm rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Nearside Rear Brake pipe slightly corroded (3.6.B.2c)

Offside Front Lower Suspension arm rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Offside Rear Brake pipe slightly corroded (3.6.B.2c)

nearside front bump stop missing and corroded hole

rear brake hose ferrule corroded