1992 Mercedes-benz Sprinter

Nearside Rear Vehicle structure is repaired but structural rigidity is not significantly reduced (6.1.1 (d) (i))

Offside Front Vehicle structure is repaired but structural rigidity is not significantly reduced door seal (6.1.1 (d) (i))

Offside Rear Vehicle structure is repaired but structural rigidity is not significantly reduced inner seal (6.1.1 (d) (i))

Nearside Rear Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced (6.1.1 (c) (i))

Offside Front Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced door seal (6.1.1 (c) (i))

Offside Front Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced door seal (6.1.1 (c) (i))

Offside Rear Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced inner seal (6.1.1 (c) (i))

Offside Rear Suspension component mounting prescribed area is corroded but not considered excessive inner sill (5.3.6 (a) (i))

Offside Front Steering component mounting prescribed area is excessively corroded inner wheel arch (2.1.2 (e) (i))

Offside Rear Suspension component mounting prescribed area is corroded but not considered excessive inner sill (5.3.6 (a) (i))

General underside corrosion

Nearside Front Wheel bearing has slight play (5.1.3 (a) (i))

Nearside Passenger seat(s) missing at time of test ()

Offside Rear Inner Tyre worn close to legal limit/worn on edge (5.2.3 (e))

exhaust silencer deteriorated

Front Exhaust mounting defective (6.1.2 (a))

General under side corrosion

Nearside Front Wheel bearing has slight play (5.1.3 (a) (i))

Nearside Front Brake hose bulging under pressure (1.1.12 (d))

Offside Headlamp not working on dipped beam (4.1.1 (a) (ii))

Front Exhaust mounting defective (6.1.2 (a))

General under side corrosion

Nearside Front Wheel bearing has slight play (5.1.3 (a) (i))

Front Exhaust has a major leak of exhaust gases (6.1.2 (a))

Front Fuel system component leaking (6.1.3 (b) (i))

Offside Hazard warning lamps inoperative (4.4.1 (e))

Nearside Front Wheel bearing has slight play (5.1.3 (a) (i))

Oil leak, but not excessive (8.4.1 (a) (i))

both rear inner wheel arches corroding

parking brake little reserve travel

Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength floor pan/inner wheel tub (5.3.6 (a) (i))

Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength floor pan/ inner wheel tub (5.3.6 (a) (i))

both rear inner wheel arches corroding

parking brake little reserve travel

Body has slight corrosion Both sides of the rear arches (6.1.B.2)

Front Anti-roll bar has slight play in a pin/bush Both D bushes (2.4.G.2)

Front Brake pad(s) wearing thin (3.5.1g)

Heavy amount of underseal used

Nearside Front Body has slight corrosion Bulk head (under bonnet) (6.1.B.2)

Rear Anti-roll bar has slight play in a pin/bush Both D bushes (2.4.G.2)

Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings Above gearbox near O/S/F anti roll bar mounting (6.1.B.2)

Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings Drivers step (6.1.B.2)

Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings Passengers step (6.1.B.2)

Bonnet cannot be secured in the closed position (8.4.1)

Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings Bulk head (could not chalk) (6.1.B.2)

Nearside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings Inner sill (6.1.B.2)

Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings Inner arch (6.1.B.2)

Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings Inner arch (6.1.B.2)

Nearside Side repeater not working (1.4.A.2c)

Offside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings Inner sill (6.1.B.2)

Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings Inner arch (6.1.B.2)

Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings Inner arch (6.1.B.2)

Offside Side repeater not working (1.4.A.2c)

Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings Near chassis leg both sides (6.1.B.2)

Rear Brake pipe excessively corroded (3.6.B.2c)

Rear fog lamp not working (1.3.2b)

Front Anti-roll bar has slight play in a pin/bush (2.4.G.2)

Front Brake pad(s) wearing thin (3.5.1g)

Nearside Front Front wheel bearing has slight play (2.5.A.3c)

Nearside Rear Gearbox cross member bolt slightly insecure

Oil leak ()

Nearside Front Brake pipe slightly corroded (3.6.B.2c)

Driver's seat insecure (6.2.A.1)

Front Brake master cylinder/servo mounting prescribed area is excessively corroded (3.6.C.3)

Nearside Front Axle king pin has excessive play in pin and/or bush adversely affecting the steering (2.5.A.3a)

Nearside Front Front position lamp(s) not working (1.1.A.3b)

Nearside Front Suspension component mounting prescribed area is excessively corroded inner arch next to shocker (2.4.A.3)

Nearside Rear Suspension spring mounting prescribed area is excessively corroded next too leaf spring (2.4.A.3)

Nearside Rear Upper Suspension spring mounting prescribed area is excessively corroded (2.4.A.3)

Offside Front Axle king pin has excessive play in pin and/or bush adversely affecting the steering (2.5.A.3a)

Offside Front Suspension component mounting prescribed area is excessively corroded inner arch (2.4.A.3)

Offside Rear Inner Tyre tread depth below requirements of 1.6mm (4.1.E.1)

Offside Rear Suspension spring mounting prescribed area is excessively corroded next too leaf spring (2.4.A.3)

Nearside Front Brake pipe slightly corroded (3.6.B.2c)

Nearside Front Axle king pin has slight play in pin and/or bush (2.5.A.3a)

Nearside Front Brake hose slightly deteriorated (3.6.B.4d)

Nearside Rear Brake pipe slightly corroded (3.6.B.2c)

Nearside Vehicle structure has slight corrosion (6.1.B.2)

Offside Vehicle structure has slight corrosion (6.1.B.2)

Driver's seat insecure (6.2.A.1)

Horn not working (1.6.2a)

Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings (6.1.B.2)

Nearside Front Windscreen wiper does not clear the windscreen effectively (8.2.2)

Nearside Passenger's seat insecure (6.2.A.1)

Offside Front Axle king pin has excessive play in pin and/or bush adversely affecting the steering (2.5.A.3a)

Offside Front Headlamp aim too low (1.8)

Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings (6.1.B.2)

Offside Rear Tyre tread depth below requirements of 1.6mm (4.1.E.1)

Nearside Front Axle king pin has slight play in pin and/or bush (2.5.A.3a)

Nearside Front Brake hose slightly deteriorated (3.6.B.4d)

Nearside Rear Brake pipe slightly corroded (3.6.B.2c)

Nearside Vehicle structure has slight corrosion (6.1.B.2)

Offside Vehicle structure has slight corrosion (6.1.B.2)

Centre Exhaust has a major leak of exhaust gases (7.1.2)

Horn not working (1.6.2a)

Nearside Front Front wheel bearing has excessive play (2.5.A.3c)

Nearside Front Headlamp aim too low (1.8)

Nearside Rear Suspension spring mounting prescribed area is deliberately modified which significantly reduces the original strength (2.4.A.3)

Offside Front Front wheel bearing has excessive play (2.5.A.3c)

near side front inner sill corroded

off side front slight play at kink pin

off side inner sill corroded

o/s r inner sill cooroded

Exhaust has a minor leak of exhaust gases (7.1.2)

Nearside Front Front wheel bearing has slight play (2.5.A.3c)

Nearside Steering pivot point has slight play (2.2.B.1g)

Offside Front Front wheel bearing has slight play (2.5.A.3c)

Offside Steering pivot point has slight play (2.2.B.1g)

n/s centre inner sill corroded

n/s/r inner sill corroded

o/s centre inner sill corroded

Horn not working (1.6.2a)

Nearside Front Seat belt anchorage prescribed area is excessively corroded (5.2.6)

Nearside Front Suspension component mounting prescribed area is excessively corroded (2.4.A.3)

Nearside Headlamp aim too high (1.8)

Nearside Rear Suspension spring mounting prescribed area is excessively corroded (2.4.A.3)

Offside Front Brake pipe inadequately clipped (3.6.B.1)

Offside Front Direction indicator not working (1.4.A.2c)

Offside Front Suspension component mounting prescribed area is excessively corroded (2.4.A.3)

Offside Front Suspension spring mounting prescribed area is excessively corroded (2.4.A.3)

Offside Rear Direction indicator not working (1.4.A.2c)

Offside Rear Suspension spring mounting prescribed area is excessively corroded (2.4.A.3)

Offside Side repeater not working (1.4.A.2c)

Exhaust has a minor leak of exhaust gases (7.1.2)

Nearside Front Front wheel bearing has slight play (2.5.A.3c)

Nearside Steering pivot point has slight play (2.2.B.1g)

Offside Front Front wheel bearing has slight play (2.5.A.3c)

Offside Steering pivot point has slight play (2.2.B.1g)

n/s centre inner sill corroded

n/s/r inner sill corroded

o/s centre inner sill corroded

o/s r inner sill cooroded

Exhaust has a minor leak of exhaust gases (7.1.2)

Exhaust has part of the system slightly deteriorated (7.1.1a)

Nearside Front Front wheel bearing has slight play (2.5.A.3c)

Offside Front Front wheel bearing has slight play (2.5.A.3c)

front bulk head corroded

rear both sides side valance corroded

Driver's door cannot be opened from outside the vehicle (6.2.B.1b)

Front Anti-roll bar has excessive play in a pin/bush (2.4.G.2)

Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings (6.1.B.2)

Nearside Front Shock absorber has a serious fluid leak (2.7.3)

Nearside Windscreen wiper blade missing (8.2.2)

Exhaust has a minor leak of exhaust gases (7.1.2)

Exhaust has part of the system slightly deteriorated (7.1.1a)

Nearside Front Front wheel bearing has slight play (2.5.A.3c)

Offside Front Front wheel bearing has slight play (2.5.A.3c)

front bulk head corroded

rear both sides side valance corroded

water leak

Front brake disc excessively scored (3.5.1h)

Indicator tell tale inoperative (1.4.A.2a)

Nearside Exhaust has part of the system excessively deteriorated (7.1.1a)

Nearside Front Leaf spring has excessive wear in a shackle pin and/or bush (2.4.B.2)

Nearside Front Side repeater not working (1.4.A.2c)

Nearside Track rod end ball joint has excessive play (2.2.B.1f)

Nearside rear brake binding (3.7.B.1)

Nearside rear brake recording little or no effort (3.7.B.5a)

Offside Front Brake pipe inadequately clipped (3.6.B.1)

Offside Front brake disc excessively pitted (3.5.1h)

Offside Rear Rear fog lamp not working (1.3.2b)

Parking brake lever has no reserve travel (3.1.6b)

Rear fog lamp tell tale not working (1.3.1b)

Steering system excessively tight (2.2.D.1)

water leak

Fuel pipe leaking (7.2.3)

Nearside Brake pipe excessively corroded (3.6.B.2c)

Nearside Front Brake pipe excessively corroded (3.6.B.2c)

Nearside Rear Brake pad(s) has restricted free movement (3.5.1k)

Nearside Seat belt anchorage prescribed area is excessively corroded (5.2.6)

Offside Front Brake hose has insufficient room to move, resulting in fouling on any part (3.6.B.4a)

Offside Windscreen wiper does not clear the windscreen effectively (8.2.2)

Parking brake: efficiency below requirements (3.7.B.7)

Vehicle Identification Number not permanently displayed (6.3.5.a)

Brake master cylinder/servo mounting prescribed area is corroded but not considered excessive (3.6.C.3)

Exhaust has a minor leak of exhaust gases (7.1.2)

Front Anti-roll bar linkage has slight play in a pin/bush (2.4.G.2)

Front Brake pipe slightly corroded (3.6.B.2c)

slight corrosion on both rear chassis