2004 Ford Tourneo Connect

Brake pipe corroded, covered in grease or other material (1.1.11 (c))

Nearside Front Wheel bearing has slight play (5.1.3 (a) (i))

welding repairs undersealed

Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i))

Parking brake efficiency below requirements (1.4.2 (a) (i))

Brake pipe corroded, covered in grease or other material (1.1.11 (c))

Nearside Front Wheel bearing has slight play (5.1.3 (a) (i))

welding repairs undersealed

Central Front Power steering pipe/hose leaking Pipes leading to rack (2.1.5 (a))

Front Headlamp has a product on the lens so that the light output is severely reduced Both sides (4.1.4 (b))

Nearside Rear Inner Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced Sill (6.1.1 (c) (i))

Offside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt CV Boot (6.1.7 (g) (ii))

Offside Front Position lamp light intensity significantly reduced (4.2.3 (a) (ii))

Offside Rear Inner Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced Outer Sill (6.1.1 (c) (i))

Parking brake efficiency below requirements (1.4.2 (a) (i))

Coolant level on minimum

Front Inner Play in steering rack inner joint(s) Both sides ()

Nearside Front Steering linkage ball joint ball joint dust cover damaged or deteriorated, but preventing the ingress of dirt Bottom ball joint cover is twisting with the hub very very small split (2.1.3 (g) (i))

Nearside Rear Wheel bearing has slight play Very slight play (5.1.3 (a) (i))

Nearside Registration plate lamp inoperative in the case of multiple lamps or light sources (4.7.1 (b) (i))

Offside Front Inner Integral body structure is corroded but structural rigidity is not significantly reduced (6.1.1 (c) (i))

Power steering fluid level below minimum (2.1.5 (b) (i))

Nearside Rear Lower inner sill corroded

Nearside Rear Wheel bearing has slight play (5.1.3 (a) (i))

Offside Front Inner Drive shaft joint constant velocity boot severely deteriorated (6.1.7 (g) (i))

Parking brake efficiency below requirements (1.4.2 (a) (i))

Nearside Rear Brake pipe corroded, covered in grease or other material before flexi (1.1.11 (c))

Nearside Rear Wheel bearing has slight play (5.1.3 (a) (i))

Offside Front Inner Drive shaft joint constant velocity boot severely deteriorated (6.1.7 (g) (i))

damp around steering rack

Nearside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt drop link (5.3.4 (b) (ii))

Offside Front Wheel bearing has excessive play (5.1.3 (a) (i))

Parking brake efficiency below requirements (1.4.2 (a) (i))

Nearside Rear Brake pipe leaking on a hydraulic braking system burst before flexi (1.1.11 (b) (ii)) DANGEROUS

Nearside Rear Brake pipe corroded, covered in grease or other material before flexi (1.1.11 (c))

Nearside Rear Wheel bearing has slight play (5.1.3 (a) (i))

Offside Front Inner Drive shaft joint constant velocity boot severely deteriorated (6.1.7 (g) (i))

damp around steering rack

Coolant leak ()

Offside Rear Brake pad(s) wearing thin Inner pad (3.5.1g)

Offside Front Inner Front constant velocity joint gaiter deteriorated, but preventing the ingress of dirt (2.5.C.1a)

Offside Rear Brake pad(s) wearing thin (3.5.1g)

Offside Rear Tyre misshaped

Rear brake disc worn, pitted or scored, but not seriously weakened (3.5.1i)

Brake pedal anti slip provision starting to deteriorate

n/s outer sill repair covered with fiberglass limiting inspection

Nearside Suspension spring mounting prescribed area is excessively corroded Outer Sill- Rear section - AS PER MARKED (2.4.A.3)

Offside Rear Registration plate lamp not working (1.1.C.1d)

Seat belt retracting mechanism defective Rear centre- does not release (5.2.5b)

Brake pedal anti slip provision starting to deteriorate

Front Exhaust has a minor leak of exhaust gases (7.1.2)

Nearside Rear Direction indicators slightly discoloured (1.4.A.2f)

Offside Front Direction indicators slightly discoloured (1.4.A.2f)

Offside Rear Direction indicators slightly discoloured (1.4.A.2f)

corrosion front discs

corrosion nearside outer sill

nearside handbrake performance down

Parking brake: efficiency below requirements (3.7.B.7)

corrosion front discs

corrosion nearside outer sill

nearside handbrake performance down

Brake pedal rubber slightly worn

Front Brake pipe slightly corroded (3.6.B.2c)

Rear Brake pipe slightly corroded (3.6.B.2c)

Windscreen has damage to an area less than a 10mm circle within zone 'A' (8.3.1a)

Nearside Front Brake pad(s) less than 1.5 mm thick (3.5.1g)

Offside Front Brake pad(s) less than 1.5 mm thick (3.5.1g)

Offside Rear Lower Anti-roll bar linkage ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt (2.4.G.2)

Offside Rear Lower Anti-roll bar linkage has excessive play in a ball joint (2.4.G.2)

Offside Rear Tyre has ply or cords exposed (4.1.D.1b)

Offside Rear Tyre not fitted in accordance with side wall instructions (4.1.D.1f)

Offside Rear Upper Anti-roll bar linkage ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt (2.4.G.2)

Brake pedal rubber slightly worn

Front Brake pipe slightly corroded (3.6.B.2c)

NSF/OSF wiper blades slightly split on ends

Rear Brake pipe slightly corroded (3.6.B.2c)

Windscreen has damage to an area less than a 10mm circle within zone 'A' (8.3.1a)

Nearside Front Tyre worn close to the legal limit (4.1.E.1)

Offside Front Tyre worn close to the legal limit (4.1.E.1)

Offside Rear Tyre worn close to the legal limit (4.1.E.1)

front brake pads worn

slight corrosion front brake pipes

Offside rear parking brake recording little or no effort (3.7.B.6a)

Parking brake: efficiency below requirements (3.7.B.7)

Nearside Front Tyre worn close to the legal limit (4.1.E.1)

Offside Front Tyre worn close to the legal limit (4.1.E.1)

Offside Rear Tyre worn close to the legal limit (4.1.E.1)

front brake pads worn

slight corrosion front brake pipes

Windscreen has damage to an area less than a 10mm circle within zone 'A' (8.3.1a)

Windscreen has damage to an area less than a 40mm circle outside zone 'A' (8.3.1d)

Nearside Rear Tyre tread depth below requirements of 1.6mm (4.1.E.1)

Windscreen has damage to an area less than a 10mm circle within zone 'A' (8.3.1a)

Windscreen has damage to an area less than a 40mm circle outside zone 'A' (8.3.1d)

Nearside Rear Tyre worn close to the legal limit (4.1.E.1)

Offside Front Brake pad(s) wearing thin (3.5.1g)

chips to screen

no seats fitted at time of test

Nearside Headlamp not working on dipped beam (1.7.5a)

Offside Rear Tyre has ply or cords exposed (4.1.D.1b) DANGEROUS

Nearside Rear Tyre worn close to the legal limit (4.1.E.1)

Offside Front Brake pad(s) wearing thin (3.5.1g)

chips to screen

no seats fitted at time of test

Offside Rear Anti-roll bar linkage has excessive play in a ball joint (2.4.G.2)

Offside rear parking brake recording little or no effort (3.7.B.6a)

Windscreen has damage to an area less than a 40mm circle outside zone 'A' (8.3.1d)

Nearside Rear Registration plate lamp not working (1.1.C.1d)

Offside Front position lamp(s) not working (1.1.A.3b)

Windscreen has damage to an area less than a 40mm circle outside zone 'A' (8.3.1d)

Centre Exhaust has a major leak of exhaust gases (7.1.2)

Front Windscreen has damage to an area in excess of a 10mm circle within zone 'A' (8.3.1a)

Rear Tyre worn close to the legal limit (4.1.E.1)